发布日期：2015-10-29 15:37:22
榨油生产线;这里我们就来说说花生脱壳机的技术与参数
| 型号 | 花生脱壳机6YL-30 |
| 产量 | 800--1000kg/h |
| 剥净率 | ≥95% |
| 清洁度 | ≥99.5% |
| 破碎率 | ≤5% |
| 动力 | 4级--4kw(380v) |
| 操作人数 | 1人 |
花生脱壳机有机架、电扇、转子、单相电机、筛网(有巨细两种)、入料斗、震动筛、三角带轮及其传动三角带等构成。 机具正常运转后，将花生定量、均匀、连续地投入进料斗，花生在转子的反复冲击、冲突、磕碰效果下，花生壳破碎。
Peanut shelling machine rack, a fan, a rotor, a single-phase motor, a sieve (size), a feed hopper, a vibration sieve, triangle belt pulley and the transmission triangle belts and the like. The normal operation of the equipment, the peanut and quantitative, uniform, continuous input into the hopper, peanut under the repeated impact of rotor, conflict and collision effect, peanut shell broken.
花生粒及破碎的花生壳在转子的旋转风压及冲击下，经过相应孔径的筛网(花生首次脱粒用大孔筛网，清选后的小皮果更换成小孔筛网进行2次脱壳)，这时，花生壳、粒遭到旋转电扇的吹力效果，重量轻的花生壳被吹出机体外，花生粒经过震动筛的挑选到达清选的意图。
Peanuts and broken peanut shell in the rotation of the rotor of wind pressure and impact, go through a certain aperture of the screen (peanut first threshing with large hole sieve, cleaning after the small pear replaced the second shell hole screen), at this time, peanut shell, particle by rotation of the electric fan blowing force effect, light weight of peanut shells blown out of the machine body, peanut tablets after shaking sieve selection at cleaning the intention.
准确运用花生脱壳机的几项请求：
The accurate use of several requests for peanut sheller:
一、对脱壳机的请求：
A, to request the sheller:
1)脱壳洁净、生产率高，对有清选设备的脱壳机，还请求有较高的清洁度。
1) shell clean, high productivity, the cleaning equipment of shelling machine, also requested the high cleanliness.
2)损失率低、破碎率小。 3)构造简略，运用牢靠，调整便利，功率耗费少，有通用性，能脱多种作物，以进步机具的利用率。
2) loss rate is low, and the breakage rate is small. 3) the structure is simple, the use of reliable, convenient adjustment, power consumption less, there will be a certain versatility, can take off a variety of crops, in order to improve the utilization of machinery.
二、对花生(皮果)的请求。花生干湿适合，太干则破碎率高;过湿则影响作业效率。乡村贮存的花生(皮果)通常较干，为使其干湿适合可采用下列办法。
Two, the peanut (fruit) request. Peanut dry and wet, too dry, high crushing rate, too wet, it will affect the operating efficiency. The village of Peanut (fruit) storage is usually dry, wet and dry to make it suitable for may adopt the following measures.
1)冬天脱壳。脱壳前用10kg摆布的温水均匀喷洒在50kg皮果上，并用塑料薄膜掩盖10小时摆布，然后再在阳光下凉晒1小时摆布即可开端脱壳，其它季节用塑料薄膜掩盖的时刻为6小时摆布，其他相同。
1) winter shelling. Shell before with 10 kg at the mercy of the warm water is uniformly sprayed on 50kg of pear, and plastic film cover 10 hours at the mercy of, and then again in the sun Liangshai 1 hour and at the mercy of can start shelling, other season with plastic film cover time for 6 hours at the mercy, same as the others.
2)可将较干的花生(皮果)浸在大水池内，浸后当即捞出并用塑料薄膜掩盖1天摆布，再在阳光下凉晒，待干湿适合后开端脱壳。
2) can be relatively dry peanuts (pear) immersed in a large pool, leaching immediately remove and plastic film cover 1 day left and right sides, again in the sun Liangshai, to be suitable for wet and dry after the start of shelling.
三、对电压的请求及作业场所的挑选。单相电动机要正常作业，电压需到达其额定电压。乡村通常一个村庄只要一个变压器，而户户又坐落涣散，加之所用电线及电路不很规范，致使离变压器较远的用户其电压不足，因而，作业场所应挑选离变压器较近的当地。
Three, the request for the voltage and the selection of the job site. Single phase motor to normal operation, voltage need to reach its rated voltage. Village is a village as long as a transformer, and household and is located and lax, coupled with the electric wire and the circuit is not very standardized, resulting in relatively far away from the transformer users the voltage is insufficient. Therefore, the workplace should choose closer to the transformer local.
郑州企鹅将可靠的设计，制造，安装经济，有质量保证的榨油行客户世界各地，如果您有任何问题，请与我们联系.0371-86661079
下面是我们为大家推荐的油脂精炼机械：
油脂浸出成套设备;http://www.qie888.com/chanpiner/
榨油机成套设备;http://www.qie888.com/chanpinsi/
油脂精炼设备；http://www.qie888.com/chanpinsan/
